SKEDSOFT

Automobile Engineering

Introduction:
                The majority of batteries now available are grouped as ‘maintenance free batteries’. This implies that a little attention is required during the life of the battery.

 

MAINTENANCE              

  • Earlier batteries and some heavier type batteries still require the electrolyte level to be checked and topped up periodically.
  • Battery posts are still a little prone to corrosion and hence the usual service of cleaning with hot water if appropriate and the application of petroleum jelly or proprietary terminal grease are still recommended.
  • Ensuring that the battery case and, in particular, the top remains clean, will help to reduce the rate of self-discharge.
  • The state of charge of a battery is very important and, in general, it is not advisable to allow the state of charge falling below 70% for long periods because the sulphate on the plates can harden, making recharging difficult.
  • If a battery is to be stored for a long period (more than a few weeks), then it must be recharged every so often to prevent it from becoming sulphated.
  •  Recommendations vary but are charge every six weeks is a reasonable suggestion.

 

MAINTENANCE FREE BATTERIES:

  • Some maintenance-free batteries incorporate a built-in hydrometer to indicate the state of charge and condition of the battery.
  • The hydrometer is color coded.
  • A green color indicates that the battery is charged and serviceable.
  • A green–black or black color indicates that the battery requires recharging.
  • A yellow color indicates that the battery is faulty.
  • Where a yellow hydrometer indicates that the battery should not be recharged or tested, and the use of jumpleads for starting should not be carried out.
  • A new battery should be fitted and the alternator checked for correct operation.
  • Battery charging can be described as slow or fast.
  • Slow charging is best but in an emergency a fast charge is acceptable.
  • When recharging, a battery should ideally be disconnected from the vehicle electrical systems.
  • There are two types of battery charger: the bench charger, which has a current output of up to about 10 A and the fast charger, which can recharge a battery in about 30 minutes, with a current of up to 50 A.